Allpar Forums banner
1 - 1 of 1 Posts

Premium Member
2,290 Posts
GEM Electric Cars

By Terry Parkhurst

Electric cars are often "the next big thing," thanks to their quiet motors, nonexistent exhaust, and the ubiquity of electric power in every other part of our lives.

Motor vehicle Mode of transport Automotive design Product Vehicle

General Motors, back in 1980, were predicting that by 1990, fully 10% of that company's product line would be powered solely by electric power. A decade later, GM built a state-of-the-art electric car, eventually destroying nearly all of them.
Chrysler built an electric minivan starting in 1993; most were sold to utilities and other fleets, but some were also sold to individuals. Chrysler had also worked on electric cars back in the 1970s, producing a four-passenger electric city car. Even the Neon was originally to be sold in diesel and electric versions.

Motor vehicle Tire Wheel Automotive tire Mode of transport

Even more prescient, or at least more determined, was the Tag 2 group in Livonia, Michigan, a group of engineers that produced their first electric vehicle in 1992. Mike Hofer, a North Dakota businessman, recognized the potential of the little car, and assembled a group of investors. He then purchased the company and moved the entire operation to Fargo in December of 1997. The result was GEM, or Global Electric Motorcar, which is still being built in Fargo, North Dakota, as what is a wholly owned subsidiary of Chrysler LLC.

The Fargo factory manufactured its first vehicle in April 1998. The 48-volt GEM could accommodate two passengers and had a top speed of just 20 miles per hour; however, less than two months later, a breakthrough in market conditions occurred when NHTSA (National Traffic Safety Administration) designated a new class of motor vehicles: the low speed vehicle called the neighborhood electric vehicle.

While a neighborhood electric vehicle didn't have to go faster than 35 mph, the NHSTA did require some things: a safety glass windshield, turn signals, mirrors, windshield wipers, headlights, taillights, and seat belts. The idea behind the neighborhood vehicle was to address both air pollution and urban sprawl; the latter was based on the theory that if you increased density in the city, there'd be less of the population going outside of the city to live. Those living in the denser environs of the city would probably want transportation other than the bus sometimes. That's where neighborhood electric vehicles would come into play.

Motor vehicle Automotive mirror Wheel Mode of transport Automotive design

In November of 1998, the first utility version of the GEM was produced. These became part of the fleet of utility vehicles at Luke Air Force based, the largest fighter pilot training facility in the world, near Phoenix, Arizona; as of 2001, there were 100 GEM vehicles in service at Luke, out of a fleet of 831 vehicles.

By the end of 1999, total production reached 1,826 vehicles; and by the end of June 2000, the monthly output had surpassed 500 vehicles. By the end of December 2000, total production had hit 5,000 vehicles.

At that time, a past Chrysler executive joined up with a competing electric-car company. Some claim it was out of spite that DaimlerChrysler quickly acquired GEM; others claim that it was, as DaimlerChrysler said, a matter of building zero-emission vehicles to supplement the slow, expensive research into hydrogen power. By then, no less than 37 states had accepted NHTSA's ruling on low speed vehicles as legal of city streets.

Tire Motor vehicle Wheel Human Mode of transport
By 2001, the GEM line of vehicles included both two and four passenger electric vehicles, as well as two utility vehicles with short and long boxes. The curb weight of the two passenger machine was just 1,100 pounds, including batteries; while the curb weight of the long box utility vehicle was just 140 pounds more.

Power was the same for the GEM fleet: a 72 volt shunt General Electric motor and six, industrial 12-volt batteries. But the major selling point was the proprietary 72-volt DC on-board charger, which employed the standard 110-volt AC house current.

GEM Motorcars LLC held an Environmental Solutions Summit in Anaheim, California in 2001. Larry Oswald, who was then CEO of GEM as well as a PhD in aerospace engineering, said that he saw his company's vehicles as "the early stages of a long range view towards a fuel cell future."

At that time (2001), we drove the GEM cars at a ride-and-drive event. They had plenty of torque, a hallmark of electric vehicles, and good handling, partly because of the independent front suspension and rear trailing-arm suspension. Having the batteries close to the ground probably helped the stable feel. The width of just 55 inches was akin to - well, a golf cart. The range was about 30 to 35 miles, enough for local grocery shopping or even typical commuting; when stopped, the GEMs consume barely any power, so stop and go traffic is not a problem.

While the vehicles still look essentially the same, there have been some major improvements since Larry Oswald's presentation. Oswald himself has retired, and Bruce Coventry is now the chief operating officer of GEM Motorcars LLC. Rick Kasper has since replaced Ken Montler, GEM's President; he holds a degree in electronic engineering technology from the University of Washington.

The battery pack is now a low maintenance gelatin type. The steering geometry has been reworked for more precise steering; and the electric motor is more responsive. There are performance upgrades for GEM cars and utility vehicles. The 7 horsepower performance package includes scoops, a heat sink, and chrome emblems.

Pricing now ranges from $6,795 for a basic two seater to a high of $17,995 for a six passenger vehicle with a truck that looks akin to something such as the add-ons you might see on a vintage motorcar of the 1920s or 1930s. [In 2016, the starting price was around $9,000.]

Mike Nickoloff, commercial fleet and GEM sales manager for Star Chrysler Jeep & GEM in Glendale, CA said, "The nice thing is you can call the manufacturer up in Fargo. It's a lot easier than trying to connect with a zone service rep for Chrysler. ... I sell maybe three or four GEM cars a month; and I usually ship them on a flatbed to my clients."

"We need infrastructure, " admitted Joan Michelson, spokesperson for GEM, in a recent phone interview. While there is still a proprietary on-board charger for GEM cars, they do, after all, have to plug into something. "We need charging stations as ubiquitous as gas stations."

Motor vehicle Wheel Mode of transport Automotive mirror Automotive design

Utilities appear happy with cars like the GEM, since they even out their demand (indeed, the Edison companies were proponents of electric cars in the early 1900s). Normally, utilities see peak demand during the day, and they need to have extra powerplants to fill that demand; but those plants often sit idle at night, an apparently needless expense. The ideal would be to either have less demand during the day (prime air conditioning, industrial use, and computer use times), or more at night. Overnight GEM recharging would provide additional utility revenue without additional capital expense.

The newest GEM line is the Peapod, designed to have an iPod appearance along with integrated iPod and iPhone controls; this model was introduced in 2008 and is a substantial upgrade to the past line.

What happened to GEM?

GEM stayed with Chrysler after it split from Daimler, and remained owned by it through the bankruptcy and Fiat deal. There was some talk of their electric car technology being used by Auburn Hills for cars such as the Fiat 500e; this was never confirmed.

In 2010, they launched right-hand-drive cars; and in mid-2011, they were quietly sold to Polaris. As of 2016, Polaris / GEM sold three passenger cars (still two, four, and six passenger) and three utilities (eS, eL, and eL XD), topping out with a 70x48 bed and 1,100 cargo capacity.

Read more about the
GEM Peapod.

Chrysler 1904-2018

Spread the word via <!--Tweet or--> Facebook!

We make no guarantees regarding validity or accuracy of information, predictions, or advice - .
Copyright © VerticalScope Inc. All rights reserved. Dodge, Jeep, Chrysler, Ram, and Mopar are trademarks of Fiat Chrysler Automobiles.

1 - 1 of 1 Posts
This is an older thread, you may not receive a response, and could be reviving an old thread. Please consider creating a new thread.